Transcription

ENGLISHSAFETY DATA SHEETtrophon NanoNebulant / trophon Sonex-HL trophon NanoNebulant / Sonex-HL is intended for use exclusively with the trophon EPR device.The product is provided to the end-consumer in fully sealed low-volume (80mL) cartridges. Undernormal use conditions, outlined in the manufacturer’s trophon EPR User Manual and cartridgeInstructions For Use (IFU), the cartridges remain sealed until they are locked into the trophon EPRdevice. Their contents are then converted to oxygen and water to ensure that operator exposure totrophon NanoNebulant / Sonex-HL is highly unlikely. The precautions taken when designing thetrophon NanoNebulant / Sonex-HL and trophon EPR system intend for it to be used with minimalpersonal protective equipment (gloves only) and in standard workplace or clinical settings, including atthe patient point-of-care. Special ventilation and other safety precautions are not required when usedas per the manufacturer’s instructions.Outside of the standard-use scenario, in bulk-transport and storage, or in an emergency situation, thefollowing measures are advised:1. IDENTIFICATION OF THE SUBSTANCE OR MIXTURE AND OF THE SUPPLIER1.1. Identification of the Substance/PreparationProduct Name:Synonyms:Commercial Product Name:Molecular Formula:Molecular Weight:Recommended use of thechemical and restrictions on use:trophon NanoNebulant, trophon Sonex-HL, HydrogenPeroxidePeroxide, Hydrogen peroxide, Hydrogen dioxidetrophon NanoNebulant, trophon Sonex-HLH2O234 g/molDisinfectant1.2. Company/Undertaking IdentificationCompany:Nanosonics LimitedAddress:14 Mars Road, Lane CoveNSW 2066, AustraliaTelephone: 61 2 8063 1600Distributed in New Zealand byCompany:Address:Telephone:Bio Decon5 Argus Place, GlenfieldAuckland 0627, New Zealand 64 9 442 40251.3. Emergency Telephone NumberTelephone:Within Australia:Toll free: 1800 039 008Land line: 03 9573 31121 of 100If ringing from overseas:Toll free: 800 2436 2255Land line: 61 3 9573 3112USA/Canada: ( 1) 877 715 9305L00106 1.0 11/2015

2. HAZARDS IDENTIFICATIONGHS ClassificationOxidising liquids (category 1)Acute toxicity, oral (category 4)Skin irritation (category 1)Serious eye damage/eye irritation (category 1)GHS Label elementOxidiserCorrosiveIrritantSignal word: DangerHazard StatementsH332: Harmful if inhaled.H302: Harmful if swallowed.H315: Causes skin irritation.H318: Causes serious eye damage.H335: May cause respiratory irritation.Precautionary statementsPreventionP261: Avoid breathing dust/ mist/ vapours/ spray.P270: Do not eat, drink or smoke when using this product.P280: Wear protective gloves/protective clothing/eye protection/ face protection.ResponseP301 P312: IF SWALLOWED: Call a POISON CENTER or doctor/ physician if you feel unwell.P302 P352: IF ON SKIN: Wash with plenty of soap and water.P304 P340: IF INHALED: Remove victim to fresh air and keep at rest in a position comfortablefor breathing.P305 P351 P338: IF IN EYES: Rinse cautiously with water for several minutes. Removecontact lenses, if present and easy to do. Continue rinsing.P310: Immediately call a POISON CENTER or doctor/physician.P312: Call a POISON CENTER or doctor/physician if you feel unwell.P330: Rinse mouth.P332 P313: If skin irritation occurs: Get medical advice/attention.P362: Take off contaminated clothing and wash before reuse.P501: Dispose of container in accordance with local/regional/national regulation.3. COMPOSITION/INFORMATION ON INGREDIENTSSubstance ydrogen Peroxide7722-84-1O, CR 8, R35 34.90 - 37.0%4. FIRST AID MEASURESIf inhaledRemove person to fresh air. If not breathing, give artificial respiration.2 of 100L00106 1.0 11/2015

Consult a physician if irritation occurs and persists.In case of skin contactRemove contaminated clothing.Wash with soap and copious amount of water.Consult a physician if irritation occurs and persists.In case of eye contactImmediately rinse thoroughly with plenty of water for at least 15 minutes and seek medicalattention.If swallowedCall a poison control centre or physician immediately. Do NOT induce vomiting unless directedby a physician.If conscious: Rinse mouth thoroughly with water.If unconscious: Never give anything by mouth to an unconscious person.5. FIRE FIGHTING MEASURESSuitable extinguishing mediaFoam, dry powder, carbon dioxide or water spray.Fire / Explosion HazardsProduct is non-combustible. Decomposition releases oxygen which may intensify fire.Special protective equipment for fire-fightersIn the event of a fire, wear self-contained breathing apparatus. Use personal protectiveequipment.Further informationEvacuate personnel to safe areas.Keep unauthorised persons away.Keep out unprotected persons.Use water spray to cool unopened containers.HAZCHEM Code:2P6. ACCIDENTAL RELEASE MEASURESPersonal precautions, protective equipment and emergency proceduresProduct causes chemical burns.Wear personal protective equipment; see section 8.Avoid breathing vapours, mist or gas and ensure adequate ventilation.Evacuate personnel to safe areas.Keep out unprotected persons.Keep away from incompatible products.Environmental precautionsAvoid release into the environment. If the product contaminates rivers, lakes or drains informrespective authorities.Small quantities may be discharged into the sewer when diluted with large quantities of water.Methods and materials for containment and clean upIf possible, dam large quantities of liquid with sand or earth.3 of 100L00106 1.0 11/2015

Dilute with plenty of water.Do not add chemical products.Never return spills to original packaging for re-use.Soak up with inert absorbent material.Dispose of in accordance with local regulations.7. HANDLING AND STORAGEPrecaution for safe handlingAvoid contact with skin and eyes. Avoid inhalation of vapour or mist.Keep away from ignition sources and organics.Use only equipment and materials which are compatible with the product.Conditions for safe storage, including any incompatibilitiesTo maintain product quality:Keep in a cool place (temperature range from -10oC to 25oC for NanoNebulant and 59oF to 77oFfor Sonex-HL).Keep in a dry and well-ventilated area.Keep away from heat and direct sun-light.Keep away from incompatible products.Keep away from combustible material.Keep in original packaging, closed.Keep upright as specified on packaging.Specific use(s)Use only with the trophon EPR.Packaging materialHDPE bottle350um fibre board and ecocoteOther informationRefer to protective measures listed in section 8.8. EXPOSURE CONTROLS/PERSONAL PROTECTIONControl ParametersOccupational Exposal Limits4 of 100L00106 1.0 11/2015

Chemical NameCAS-No.ValueControl parametersBasisHydrogen peroxide7722-84-1TWA1 ppmACGIHTWA1 ppm1.4 mg/m375 ppm IDLHNIOSHTWA1 ppm1.4 mg/m3OSHAEngineering measuresEnsure adequate ventilation. Refer to the personal protective measures below.Personal protective equipmentRespiratory protection:No personal respiratory protective equipment is normally required. However, if workplaceexposure limit is exceeded, apply respiratory protective equipment.Use only respiratory protection that conforms to the international/national standards.Hand protection:Wear suitable gloves.Recommended materials: PVC, rubberEye protection:For normal handling of cartridges, when used with the trophon EPR according to themanufacturers’ instructions, no eye protection is normally required.If in a spill or bulk-handling situation, chemical resistant goggles must be worn.If risk of splashing, chemical proof goggles/face shield must be worn.Skin and body protection:For normal handling of cartridges, when used with the trophon EPR according to themanufacturers’ instructions, body protection is not normally required, except for gloves.If in a spill, bulk-handling or direct chemical contact situation, a protective suit must be worn.If risk of splashing, PVC or rubber apron/boots must be worn.Hygiene measures:Handle in accordance with good hygiene and safety practice.When using, do not eat, drink or smoke.9. PHYSICAL AND CHEMICAL PROPERTIESGeneral Information (appearance, tly pungent5 of 100L00106 1.0 11/2015

Important Health Safety and Environmental InformationpH:1-4Boiling point/range:Flash point:108 C (H2O2 35%)Flammability (solid, gas):Explosive properties:The product is not flammable.Explosive only at high temperatures and when incontact with organic solvents.Oxidizing properties:Vapour pressure:Remarks: OxidizerDoes not flash12 mbar Temperature: 20 CRemarks: Total pressure (H2O2 H2O) (H2O2 50%)72 mbar Temperature: 50 CRemarks: Total pressure (H2O2 H2O) (H2O2 50%)1 mbar Temperature: 30 CRemarks: Partial pressure (H2O2 H2O) (H2O2 50%)Relative density/ Density:Solubility:1.13 (H2O2 35%)Soluble in: WaterPolar organic solventsPartition coefficient (n- octanol/water):Log Pow: -1.1Viscosity:1.07mPa.s Temperature: 20 C (H2O2 27.5%)Vapour density:1 (H2O2 50%)Miscibility in water:Completely miscible10. STABILITY AND REACTIVITYReactivity:Reactive with reducing agents, organic solvents, organic compounds and metals.Chemical Stability:Stable under normal ambient and anticipated storage and handling conditions of temperature andpressure. Contains a stabilizer.Possibility of hazardous reactions:Explosive at high temperatures and when in contact with organic solvents.Conditions to avoid:Direct sunlight and heat.Incompatible materials:Strong acids, strong bases, heavy metal salts, reducing agents and combustible material.Hazardous decomposition products:Oxygen, steam.6 of 100L00106 1.0 11/2015

11. TOXICOLOGICAL INFORMATIONHealth effectsToxicological dataAcute oral toxicity:LD50, rat. 1,232 mg/kg (H2O2 35%)Acute inhalation toxicity:LD50, 4h, rat, 2,000 mg/m3 (Hydrogenperoxide)LC0, 1h, mouse, 2,170 mg/m3 (Hydrogenperoxide)Acute dermal toxicity:LD50, rabbit, 2,000 mg/kg (H2O2 35%)Skin irritation:Rabbit, irritant (skin) (H2O2 50%)Inhalation:Irritation to respiratory tract and can causeinflammation of the respiratory tract andpulmonary oedema.Eye contact:Extreme irritation, watering, redness andswelling of the eyelids.Risk of irreversible damage.Skin contact:Causes caustic burns.Irritation and temporary whitening atcontact area.Ingestion:May lead to bleeding of the mucosa in themouth, oesophagus and stomach.May be fatal if swallowed.Eye irritation:Rabbit, Risk of serious damage to eyes.(H2O2 35%)Sensitization:Guinea pig: not sensitizingChronic toxicity:Oral, prolonged exposure, rat/mouse,Target organs: gastro-intestinal system,observed effectGenetic toxicity in vitro:In vitro, without metabolic activation,mutagenic effects.Genetic toxicity in vivo:In vivo, animal testing did not show anymutagenic effects.12. ECOLOGICAL INFORMATIONEcotoxicityAcute toxicityFishes, Pimephales promelas, LC50, 96h,16.4 mg/lFishes, Pimephales promelas, NOEC, 96h,5 mg/lCrustaceans, Daphnia pulex, EC50, 48h,2.4 mg/lCrustaceans, Daphnia pulex, NOEC, 48h, 1mg/l7 of 100Chronic toxicityRemarks: no data availableAlgae, various species, EC50, from 72 – 96h,from 3.7 – 160 mg/lRemarks: fresh waterAlgae, Nitzchia closterium, EC50, from 72 – 96,0.85 mg/lRemarks: salt waterL00106 1.0 11/2015

Persistence and degradabilityAbiotic degradationAir, indirect photo-oxidation, t 1/2 from 10 20 hConditions: sensitizer: OH radicalsWater, redox reaction, t 1/2 from 2.5 d,10000 ppmConditions: mineral and enzymaticcatalysis, fresh waterWater, redox reaction, t 1/2 from 20 d,100 ppmConditions: mineral and enzymaticcatalysis, fresh waterWater, redox reaction, t 1/2 from 60 hConditions: mineral and enzymaticcatalysis, salt waterSoil, redox reaction, t 1/2 from 15 hConditions: mineral catalysisBiodegradationAerobic, t 1/2 1 minConditions: biological treatment sludgeRemarks: rapid and considerable biodegradationAerobic, t 1/2 from 0.3 - 2 dConditions: fresh waterRemarks: rapid and considerable biodegradationAnaerobicRemarks: not applicableEffects on waste water treatment plants, Inhibitor 200 mg/lRemarks: inhibitory actionBioaccumulative potentiallog Pow -1.1Result: non-bioaccumulable (enzymatic metabolism)Other adverse effectsNot known13. DISPOSAL CONSIDERATIONSWaste from unused productsIn accordance with National, Federal, State and Local regulations.Contaminated packagingEmpty containers should be taken to an approved waste handling site for recycling or disposaland in accordance with National, Federal, State and Local regulations.14. TRANSPORT INFORMATIONMode of transport: Sea, road and rail.Mode of transport to avoid: Air – STRICTLY NO AIR FREIGHT.8 of 100L00106 1.0 11/2015

Other information:HI/UN-No:Transport Hazard Class:Subrisk 1:Packing Group:Proper Shipping Name or Technical Name:Marine Pollutant:IMO Labels:ADG Labels:IMDG EMS Fire:IMDG EMS Spill:HAZCHEM Code:58/20145.1 Oxidizing Agent8 CorrosiveIIHYDROGEN PEROXIDE, AQUEOUSSOLUTIONNoOXIDISING AGENT CORROSIVE5.1 8F-HS-Q2P15. REGULATORY INFORMATIONLabelHazardous components which must be listed on the label: Hydrogen peroxideSymbol(s)CCorrosiveR-phrase(s)R34Causes burnsS1/2Keep locked up and out of the reach of childrenS3Keep in a cool placeS28After contact with skin, wash immediately with plenty of water.S-phrase(s)S36/39Wear suitable protective clothing and eye/face protectionIn case of accident or if you feel unwell, seek medical adviceS45immediately (show the label where possible)See Section 2 for applicable GHS and CLP Hazard and Precautionary StatementsInternational InventoriesToxic Substance Control Act list (TSCA)In compliance with inventory.Australian Inventory of Chemical Substances (AICS)EU list of existing chemical substances (EINECS)New Zealand HSNO regulatory information:HSR001326 class 5.1.1BIn compliance with inventory.In compliance with inventory.In compliance with inventory.The German Federal Water Management ActWater Hazard Class (WHC):ClassHazard PotentialWHC 1Slightly hazardous to water16. OTHER INFORMATIONThe information provided in this Safety